Purchased equipment: 22 and 14 mw bagasse power plant
Location: WUXI China
Telephone: +86 13861509127
E-mail: [email protected]
Contact us for more details about our boilers, solutions and services.

22 and 14 mw bagasse power plant
Others

Molten salt heaters use molten potassium nitrate and sodium nitrite as heating media. Molten salt heater will heat the powder salt over the melting point until the viscosity of the molten salt allows circulating pump works, after the whole system is under circulating condition, then feed then into the thermal fluid heater for further circulating rising temperature to make it to be recycling used. Normal media working temperature is 400-550℃, top working temperature could reach 600℃.

Technical advantages

Digitized manufacture

  • The laying-off of steel tube adopts CNC 3D laser cutting machine.
  • The manufacture of square coil tube adopts CNC three-dimensional tube bending machine, no forced shaping.
  • The manufacture of serpentuator adopts serpentuator automatic production line, once-forming.

Long life span

  • The optimized radiation heating surface and convective heating surface, the medium flow is more reasonable, without overheat of the carrier and reduce the life;
  • Convection section: optimize convection heating surface and adopt effective fix and structural support to make its working life longer.
  • Set up effective flue gas partition for convection heating surface and cast partition to make it works longer.

Less fuel consumption

  • Use superior refractory brick to build inside and superior perlite in the middle. Keep the furnace temperature under 50℃ to make the minimization of loss.
  • Furnace adopts double close line coil, which makes heating surface sufficient.

Add Comment

Biomass Power: High Efficiency Boiler Technology for Suga

Bio Power: Bagasse from sugar production is used in biomass power plants with total capacity of 307 MW in which 177 MW is fed to national grid around 1,000 GWH annually.

Bagasse and Blended Biomass Cogeneration Advances in th

Today there are 185 bagasse-fired boilers installed in 56 sugar factories all around the country, with a total power capacity of 532.1 MW, and all sugar factories operate under the cogeneration

RENEWABLE ENERGY ADDITIONAL CAPACITY under RA9513 - doe.gov.

14.8 MW Montalban Landfill Methane Recovery and Power Generation Facility Montalban Methane Power Corporation 8.33 4-Sep-2009 BREOC No. 2010-01-005 21 MW FFHC Bagasse-Fired Cogeneration Power Plant First Farmers Holding Corp. 21.00 January 2010 HSC No. 2010-03-131 Ambangal Hydroelectric Power Plant Provincial Government of Ifugao 0.20

Details of Bagasse/ Biomass Cogeneration Project

14. Deoband Bagasse Based Cogeneration Power Project 11/03/2006 15. 1.5 MW Biomass / Bagasse Based Cogeneration Power Project at Kurkumbh, Maharashtra 15/12/2006 16. Biomass Based captive Cogeneration Project at Shri Renuga Textiles Ltd 29/12/2006 17. Rice Husk Based Cogeneration Power Plant-II at SBPML 15/01/2007 18.

Bagasse - A Sustainable Energy Resource from Sugar Mills-Ed

The power plant generally operates at approximately 25.5 MW, utilizing 17.5 MW for the sugar factory and power plant itself and selling the excess 8 MW to the grid under the Small Power Producers (SPPs) scheme. Figure 1 shows the flow diagram of the power plant. Fig. 1 Ratchasima Sugar Factory’s power plant.

Bagasse | BioEnergy Consu

The surplus exportable electricity in Mauritian power plants has been based on a fibre content ranging from 13- 16% of sugarcane, 48% moisture content in Bagasse, process steam consumption of 350–450 kg steam per ton sugarcane and a power consumption of 27-32 kWh per ton sugarcane.

Sugar cane bagasse energy cogeneration Lessons fro

Firstly, the utility could add 2 units of 24 MW each to its existing 4 units. Secondly, it could invest in a 40-50 MW coal plant. The third option would comprise of bulk purchasing of power from 2 x 22 MW bagasse cum coal plants, to be privately operated by sugar companies at 2 regional sugar factories.

Cogeneration - Department of Energy Science and Engineeri

Power Plant Fuel Fuel Cogen Plant Fuel Electricity Electricity Heat 2.5 MW 6 ata BAGASSE 22 ata 58 T/hr 330o C 4.5T/hr 27T/hr 26T/hr Schematic of typical 2500 tcd Sugar factory Import Power from Grid with Cogeneration for a Petrochemical Plant 11 MW 17.6 21.6 0 0 5 10 15 20 25

VALIDATION OF THE 24 MW G PROJECT - UNFC

MW Bagasse based cogeneration power plant (hereafter called “the project”) at Samirvadi, Mudhol Taluk, District Bagalkot, Karnataka India. This report summarizes the findings of the validation of the project, performed

Report on Review of Performance of the Grid Connecte

2009 UNDP / GEF Biomass Power Project Report on Review of Performance of the Grid Connected Biomass Based Power Plants Installed in South India

PPT – Case study on Bagasse Energy Cogeneration i

Chart and Diagram Slides for PowerPoint - Beautifully designed chart and diagram s for PowerPoint with visually stunning graphics and animation effects. Our new CrystalGraphics Chart and Diagram Slides for PowerPoint is a collection of over 1000 impressively designed data-driven chart and editable diagram s guaranteed to impress any audience.

text