Purchased equipment: 25 tons waste heat boiler power generation
Location: WUXI China
Telephone: +86 13861509127
E-mail: [email protected]
Contact us for more details about our boilers, solutions and services.

25 tons waste heat boiler power generation

Molten salt heaters use molten potassium nitrate and sodium nitrite as heating media. Molten salt heater will heat the powder salt over the melting point until the viscosity of the molten salt allows circulating pump works, after the whole system is under circulating condition, then feed then into the thermal fluid heater for further circulating rising temperature to make it to be recycling used. Normal media working temperature is 400-550℃, top working temperature could reach 600℃.

Technical advantages

Digitized manufacture

  • The laying-off of steel tube adopts CNC 3D laser cutting machine.
  • The manufacture of square coil tube adopts CNC three-dimensional tube bending machine, no forced shaping.
  • The manufacture of serpentuator adopts serpentuator automatic production line, once-forming.

Long life span

  • The optimized radiation heating surface and convective heating surface, the medium flow is more reasonable, without overheat of the carrier and reduce the life;
  • Convection section: optimize convection heating surface and adopt effective fix and structural support to make its working life longer.
  • Set up effective flue gas partition for convection heating surface and cast partition to make it works longer.

Less fuel consumption

  • Use superior refractory brick to build inside and superior perlite in the middle. Keep the furnace temperature under 50℃ to make the minimization of loss.
  • Furnace adopts double close line coil, which makes heating surface sufficient.

Add Comment

Waste Heat Recovery for the Cement Sector - I

viii Waste Heat Recovery for the Cement Sector This report analyzes the current status of Waste Heat Recovery (WHR) technology deployment in developing countries and investigates the success factors in countries where WHR has become widely spread.

Waste Heat Boiler Case, WHRB Project -- ZBG Boil

75 Tons Chemical Three Castoff Waste Heat Boiler >> Application:Chemical waste recycling Capacity:75 tons 25Y08 Waste Heat Boiler Used in Chemical Company >> Application:Chemical industry Capacity:25 tons 50 Ton Waste Heat Boiler for Power Plant in Vietnam >> Application:Power generation


Waste Heat Recovery Power Plants, contribute significantly, to the electrical energy saving (to the tune of 25%). The reduction in CO 2 emission, makes it environmental friendly. Installation of the waste heat recovery plant has to be tackled as a system approach, rather than considering cement plant and WHRPP operations, independently.

Boiler project, ZBG projects in the world,-ZBG Boil

49 Tons Waste Heat Steam Boiler Project. Application: Capacity: 65 Ton Gas Fired Power Plant Boiler Project. Application: power generation. Capacity: 65 ton. 20 Ton Biomass Power Plant Boiler in China. Application: Capacity: 25 ton. 24 Sets of Flue Gas Waste Heat Recovery Boiler Project.

Carbon Rotary Kiln Waste Heat Boiler--Z

20 Ton Waste Heat Boiler In Vietnam Power Plant >> Application: Power plant Capacity: 20 tons QC20.4/1130-7-1.6 Hazardous Waste Incineration Waste Heat Boiler >> Application: Hazardous waste incineration Capacity: 7 tons 50 Ton Waste Heat Boiler for Power Plant in Vietnam >> Application: Power generation

Waste Heat Recovery - The Heat is Power Associati

Waste Heat Recovery Opportunity Areas Table 7 ­Options for Heat Recovery via Power Generation 25 Table 8 ­Comparison of Heat Recovery Technologies 30 Table 9 ­Status of Waste Heat Recovery Technologies in Selected Applications 31 economizer, waste heat boiler,


Estimates of the amount of industrial waste heat available at a temperature high enough for power generation with today’s technologies (i.e., >500 o F) are in the range of 0.6 to 0.8 Quads (or 6,000 to 8,000 megawatts [MW] of

Analysis of waste heat generation technology in China -

In the late 80 s to the early 80 s, in solves the waste heat boiler after many of the major technical problems and difficulties, tons of clinker waste heat power generation is

Technology The Spittelau Thermal Waste Treatment Pla

For power generation, this steam is first reduced to 4.5 bar waste heat boiler at a tempera-ture of 180 °C, and is initially cleaned by the 3-stage electro- makes the Spittelau Thermal Waste Treatment Plant one of the most environmentally friendly plants in the world.

Waste-heat Power Plant Put into Commissioning b

The waste-heat power-generation steam turbine unit (No.1) under the circular-economy coal-coking expansion project (with an annual output of 1.3 million tons) of Guizhou

Waste Heat Recovery Boilers In Japan - kwelaxpress.co.

2015/08/24· Waste heat recovery steam boiler manufacturer in India: Waste heat Boiler,Waste Heat Boiler Manufacturer in China: Email address : 5 : 2.1KHitachi Zosen's Panel Boiler-type Waste Heat Recovery About Hitachi Zosen's panel boiler-type waste heat recovery and power generation system for small waste incineration plant 1.